Product ID:ELDORADO CT-2400 CARBON REMOVER
MSDS Date:01/05/2000
FSC:6850
NIIN:00-543-7801
Status Code:A
MSDS Number: CKBYR

ELDORADO CHEMICAL COMPANY, INC.

14350 LOOKOUT ROAD
SAN ANTONIO, TX 78265-4837
US

Emergency Phone: 800-265-3924

Info Phone: 210-653-2060/FX2106530825

Preparer: BOB E. FLYNT

Cage: 55208

ELDORADO CHEMICAL COMPANY, INC.

34837 SAN ANTONIO, TX 78265-4837 US

Telephone: 800-531-1088/ 210-653-2060

Cage: 55208

DICHLOROMETHANE

CAS: 75-09-2

RTECS: PA8050000

OSHA PEL SEE TABLE Z-2, 25PPM

ACGIH TLV: 174 MG/M3;50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

PHENOL

CAS: 108-95-2

RTECS: SJ3325000

OSHA PEL 19 MG/M3;5 PPM

ACGIH TLV: 19 MG/M3;5 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

CRESOL

CAS: 1319-77-3

RTECS: GO5950000

OSHA PEL 22 MG/M3;5 PPM

ACGIH TLV: 22 MG/M3;5 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SODIUM CHROMATE

CAS: 7751-11-3

ACGIH TLV: 0.5 MG/M3

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: INHALATION: SEVERE. SYSTEMIC,
CUMULATIVE POISON, LIVER AND KIDNEY DAMAGE MAY RESULT. SKIN:
SEVERE. CORROSIVE TO SKIN. SKIN ABSORPTION: SEVERE. CUMULATIVE
POSON, SUSPECTED CARCINOGEN BY ANIMAL S TUDIES. EYES: HIGH.
CORROSIVE TO EYE CONTACT. SHORT EXPOSURE WILL CAUSE HAZY VISION
WHICH SHOULD RETURN TO NORMAL. CHRONIC: INHALATION: SEVERE.
CUMULATIVE POISON, LIVER AND KIDNEY DAMAGE MAY RESULT. SKIN:
SEVERE. CUMULATIVE POISON, SUSPECTED CARCINOGEN BY ANIMAL STUDIES.
SKIN ABSORPTION: SEVERE. CUMULATIVE POISON, SUSPECTED CARCINOGEN BY
ANIMAL STUDIES. EYES: SLIGHT. PAIN SHOULD PRECLUDE CHRONIC
EXPOSURE. NO CHRONIC EFFECTS EXPECTED.
Explanation of Carcinogenicity:CUMULATIVE POISON, SUSPECTED CARCINOGEN
BY ANIMAL STUDIES.
Effects of Overexposure:INHALATION: LIVER AND KIDNEY DAMAGE. SKIN: SKIN
CORROSION. EYES: CORROSIVE TO EYES, HAZY VISION. PAIN SHOULD
PRECLUDE CHRONIC EXPOSURE.

First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SEEK MEDICAL
ATTENTION IMMEDIATELY. SKIN: WASH WITH SOAP AND WATER SEEK MEDICAL
ATTENTION. INHALATION: MOVE TO FRESH AIR. GIVE OXYGEN IF NEEDED.
SEEK ME DICAL ATTENTION IMMEDIATELY. INGESTION: DO NOT INDUCE
VOMITING. CONSULT A PHYSICIAN IMMEDIATELY.

Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NONE
Lower Limits:N0NEA
Upper Limits:NONE
Extinguishing Media:NONE
Fire Fighting Procedures:SCBA IS REQUIRED. AVOID SKIN CONTACT.
Unusual Fire/Explosion Hazard:CONTACT WITH FLAME MAY PRODUCE TOXIC
CHLORINE FUMES AND/OR PHOSGENE GAS.

Spill Release Procedures:CONTAIN AND CLEANUP SPILLS WITH ABSORBENT. DO
NOT ALLOW INTO DRAINS, SEWERS, STREAMS, OR WATER WAYS.

Handling and Storage Precautions:AVOID SKIN CONTACT. WASH WITH SOAP AND
WATER AFTER USE. DO NOT USE IN A CONFINED SPACE.AVOID CONACT WITH
RUBER, ASPHALTIC BASE FLOORS, AND WALKWAYS. STORE INDOORS, OR IN AN
AREA WELL PROTECTED AGAINST POOR WEATHER CONDITIONS. STORE BELOW
80F. DISCARD ANY BULGING OF DISTORTED CONTAINERS.
Other Precautions:CONTENTS MAY BE UNDER PRESSURE IN STORAGE. OPEN
CAUTIOUSLY. INTENDED USE: CARBON REMOVING COMPOUNDS UNDER, THESE
SPECIFICATION, ARE INTENDED FOR REMOVING OR LOOSINING CARBON FROM
COMPONENTS OF INTERNA L COMBUSTION ENGINES AND COMPRESSOR SECTIONS
OF JET ENGINES BY MEANS OF IMMERSION AT ROOM TEMPERATUR E IN
AGITATED TANKS.

Respiratory Protection:OSHA/NIOSH APPROVED RESPIRATORY PROTECTION.
Ventilation:100 FT MIN. AIR FLOW.
Protective Gloves:CHEMICAL RESISTANT.
Eye Protection:GOGGLES AND FACE SHIELD.
Other Protective Equipment:RUBBER BOOTS AND RAIN SUITS, FULL WASH RACK
GEAR.
Work Hygienic Practices:AVOID SKIN CONTACT, WASH WITH SOAP AND WATER
AFTER USE. DO NOT USE IN A CONFINED SPACE.
Supplemental Safety and Health
THESE COMPOUNDS MAY BE USED EFFECTIVELY IN CONJUNCTION WITH ULTRASONIC
CLEANING DEVICES WHEN SUPPLIED WITHOUT SEAL. WATER OF A 0.5 TO 1.0%
SODIUM CHROMATE SOLUTION SHOULD BE ADDED TO RETARD EVAPORATIO N.
TYPE 1 MATERIAL SHOULD BE LIMITED TO ACTIVITIES THAT ARE EQUIPPED
FOR THE DISOSAL OF PHENOLS

HCC:B2
Boiling Pt:=46.1C, 115.F
Vapor Pres:200 MMHG @ 20C
Vapor Density:2
Spec Gravity:1.18
pH:12
Evaporation Rate & Reference:1 (WATER=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:DUAL PHASE, AMBER LIQUID, STRONG DISINFECTANT ODOR.
Percent Volatiles by Volume:90

STRONG OXIDIZERS.
Hazardous Decomposition Products:CHLORINE FUMES AND/OR PHOSGENE GAS MAY
BE PRODUCED DURING COMBUSTION.

Waste Disposal Methods:SEPA HAZARDOUS WASTE NO.'S: ASIS THIS PROCICT
HAS A DOOT EPA HAZARDOUS WASTE CODE. CONSULT FEDERAL, STATE, AND
LOCAL REGULATORY AGENCIES FOR PROPER DISPOSAL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:THIS PRODUCT CONTAINNS MATERIALS THAT HAVE BEEN DETERMINED
BY D.O.T., IMDG, AND IATA TO BE MARINE POLLUTANTS AVOID
CONTAMINATING ALL WATERWAYS, LAKES, STREAMS, AND OTHER WATER AREAS.

Transport Information:PER MANUFACTURERS MSDS: SHIPPING NAME (DOT):
CORROSIVE LIQUID, N.O.S. (DICHLOROMETHANE AND CRESOLS) CLASS 8,
UN1760, PKG II. THIS DMA ENTRY IS USIN THE MORE DESCRIPTIVE PROPER
SHIPPING NAME: CORROSIVE LIQUID, BASIC, ORGANIC, N.O.S. , CLAS 8,
UN3267, PKG II, (DICHLOROMETHANE AND CRESOLS).

Federal Regulatory Information:ALL MATERIALS USED IN THE MANUFACTURING
HAVE BEEN CERTIFIED BY THEIR MANUFACTURER AS BEING ON OR EXET FROM
THE CURRENT TSCA INVENTORY.